Explore the vast range of titles available.

Letter to the Editor

The increasing awareness of endotoxin contamination has raised important questions during the study of the mechanism of action of the vaccine adjuvants. The endotoxins or lipopolysaccharides (LPS) can contaminate vaccine formulations contributing to result misinterpretations of the in vitro and in vivo studies. In this short communication, we considered the suitability of the Limulus amebocyte lysate (LAL) assay to quantify chitosan (Chit) nanoparticle (NP) endotoxin contamination to use them in a comparative in vitro immunotoxicology study using both LPS-free (LF) and non-LF Chit NPs. It was shown that chit NPs had a masking effect on endotoxin levels, hampering a reliable conclusion about the effect of their contamination. Neither non-LF nor LF Chit NPs induced the production of ROS in RAW 264.7 cells or IL-6 and TNF-α in PBMCs. The lack of effect of non-LF NPs was not expected and likely due to the NPs masking effect, more evident for higher deacetylation degree Chit. Overall, to prevent questionable results, nanomaterials should be produced under endotoxin-free conditions.

Nanomaterials may be contaminated with bacterial endotoxin during production and handling, which may confound toxicological testing of these materials, not least when assessing for immunotoxicity. In the present study, we evaluated the conventional Limulus amebocyte lysate (LAL) assay for endotoxin detection in graphene based material (GBM) samples, including graphene oxide (GO) and few-layered graphene (FLG). Our results showed that some GO samples interfered with various formats of the LAL assay. To overcome this problem, we developed a TNF-α expression test (TET) using primary human monocyte-derived macrophages incubated in the presence or absence of the endotoxin inhibitor, polymyxin B sulfate, and found that this assay, performed with non-cytotoxic doses of the GBM samples, enabled unequivocal detection of endotoxin with a sensitivity that is comparable to the LAL assay. FLG also triggered TNF-α production in the presence of the LPS inhibitor, pointing to an intrinsic pro-inflammatory effect. Finally, we present guidelines for the preparation of endotoxin-free GO, validated by using the TET.

Gram-negative bacteria-derived lipopolysaccharides (LPS) are associated with various negative health effects. Whether diet is associated with LPS, is an understudied phenomenon. We investigated the association between diet and serum LPS activity in 668 individuals with type 1 diabetes in the FinnDiane Study. Serum LPS activity was determined using the Limulus Amoebocyte Lysate assay. Diet was assessed with a food frequency questionnaire (FFQ) section of a diet questionnaire and a food record. The food record was used to calculate energy, macronutrient, and fibre intake. In a multivariable model, energy, macronutrient, or fibre intake was not associated with the LPS activity. Using factor analysis, we identified seven dietary patterns from the FFQ data (“Sweet”, “Cheese”, “Fish”, “Healthy snack”, “Vegetable”, “Traditional”, and “Modern”). In a multivariable model, higher factor scores of the Fish, Healthy snack, and Modern patterns predicted lower LPS activity. The validity of the diet questionnaire was also investigated. The questionnaire showed reasonable relative validity against a 6-day food record. The two methods classified participants into the dietary patterns better than expected by chance. In conclusion, healthy dietary choices, such as consumption of fish, fresh vegetables, and fruits and berries may be associated with positive health outcomes by reducing systemic endotoxaemia.

Pyrogens are classified in two groups, endotoxin pyrogens and non-endotoxin pyrogens (NEPs). The presence of either in parenteral pharmaceuticals or medical devices can cause severe harm to subjects, and when occurring in combination, synergistic potentiation effects can occur. As the standard in vitro pyrogen test, the Limulus Amebocyte Lysate (LAL) assay can detect LPS only, an endotoxin, but not NEPs. We tested whether the Monocyte Activation Test (MAT) that measures IL-6 induction, is suited for detecting synergistic pyrogen effects. Here we show that MAT reliably detects the NEPs heat-killed Staphylococcus aureus, R848 and lipoteichoic acid, in addition to LPS. When combinations of these pyrogens were tested, a potentiation of IL-6 production was seen beyond an additive effect, apparently reflecting on in-vivo synergisms. The current study therefore demonstrates that MAT not only is a reliable and reproducible assay for the sensitive detection of both endotoxin and non-endotoxin pyrogens, but also for identifying synergistic effects when parenteral drugs are contaminated with multiple pyrogens.

The pharmaceutical industry is developing increasing numbers of drugs and diagnostics based on nanoparticles, and evaluating the immune response to these diverse formulations has become a challenge for scientists and regulatory agencies alike. An international panel of scientists and representatives from various agencies and companies reviewed the imitations of current tests at a workshop held at the National Cancer Institute in Frederick, Maryland. This article outlines practical strategies for identifying and controlling interferences in common evaluation methods and the implications for regulation.

Air samples were collected on glass fibre filters in 22 animal houses and 3 hay storage barns and examined for the presence of bacterial endotoxin with the Limulus (LAL) test and the gas chromatography-tandem mass spectrometry (GC-MSMS) technique, based on detection of 3-hydroxy fatty acids (3-OH-FAs) as chemical markers of the endotoxin lipopolysaccharide. The median concentrations of airborne endotoxin determined with LAL test in poultry houses, sheep sheds, piggeries, cow barns, and horse stables were respectively 62.49 microg/m3, 26.2 microg/m3, 3.8 microg/m3, 1.65 microg/m3, and 1.14 microg/m3, while those determined with the GC-MSMS technique were respectively 1.06 microg/m3, 7.91 microg/m3, 0.2 microg/m3, 0.31 microg/m3, and 1.42 microg/m3. The median concentrations of airborne endotoxin determined with LAL test and GC-MSMS technique in hay storage barns were much smaller, 0.09 microg/m3 and 0.03 microg/m3, respectively. The concentrations of airborne endotoxin (LPS) detected with GC-MSMS method in the air of sheep sheds were significantly greater than in all other examined facilities, while those detected in hay storage barns were significantly smaller than in all other examined facilities (p<0.05). The concentrations of airborne endotoxin determined with LAL test and GC-MSMS analysis exceeded in most of animal houses examined (91% by each method) the threshold limit value for airborne endotoxin of 0.1 microg/m3 proposed by various authors. A significant correlation (p<0.05) between the concentrations of endotoxin determined with the LAL and GC-MSMS techniques was found in the air samples collected in poultry houses and sheep sheds, but not in other examined facilities. 3-OH FAs with C14-C18 chains were predominant in the air of the facilities under study. A significant correlation (p<0.05) was found between the concentrations of endotoxin determined with LAL test and the amounts of 3-OH FAs with C14-C16 chains. In conclusion, endotoxin in the concentrations detected in this study may present a respiratory hazard to both humans and livestock animals.

Acellular bacterial ghosts (BGs) are empty non-living bacterial cell envelopes, commonly generated by controlled expression of the cloned lysis gene E of bacteriophage PhiX174. In this study, Vibrio parahaemolyticus ghosts (VPGs) were generated by chemically-induced lysis and the method is based on minimum inhibitory concentration (MIC) of sodium hydroxide (NaOH), acetic acid, boric acid, citric acid, maleic acid, hydrochloric acid, and sulfuric acid. The MIC values of the respective chemicals were 3.125, 6.25, <50.0, 25.0, 6.25, 1.56, and 0.781 mg/mL. Except for boric acid, the lysis efficiency reached more than 99.99% at 5 min after treatment of all chemicals. Among those chemicals, NaOH-induced VPGs appeared completely DNA-free, which was confirmed by quantitative real-time PCR. Besides, lipopolysaccharides (LPS) extracted from the NaOH-induced VPGs showed no distinctive band on SDS-PAGE gel after silver staining. On the other hand, LPS extracted from wild-type bacterial cells, as well as the organic acids-induced VPGs showed triple major bands and LPS extracted from the inorganic acids-induced VPGs showed double bands. It suggests that some surface structures in LPS of the NaOH-induced VPGs may be lost, weakened, or modified by the MIC of NaOH. Nevertheless, Limulus amoebocyte lysate assay revealed that there is no significant difference in endotoxic activity between the NaOH-induced VPGs and wild-type bacterial cells. Macrophages exposed to the NaOH-induced VPGs at 0.5 × 106 CFU/mL showed cell viability of 97.9%, however, the MIC of NaOH did not reduce the cytotoxic effect of wild-type bacterial cells. Like Escherichia coli LPS, the NaOH-induced VPGs are an excellent activator of pro-inflammatory cytokines (IL-1β and iNOS), anti-inflammatory cytokine (IL-10), and dual activities (IL-6) in the stimulated macrophage cells. On the other hand, the induction of TNF-α mRNA was remarkable in the macrophages exposed with wild-type cells. Scanning electron microscopy showed the formation of trans-membrane lysis tunnel structures in the NaOH-induced VPGs. SDS-PAGE and agarose gel electrophoresis also confirmed that cytoplasmic proteins and genomic DNA released from the VPGs to culture medium through the lysis tunnel structures. Taken together, all these data indicate that the NaOH-induced VPGs show the potency of a safe, economical, and effective inactivated bacterial vaccine candidate.

Many nanoparticles interfere with traditional tests to quantify endotoxin. The aim of this study was to compare the performance of limulus amoebocyte lysate (LAL) formats on clinical-grade nanoformulations, to determine whether there were disparate results among formats and to test the applicability of an alternative bioassay (the macrophage activation test [MAT]) for resolving discrepancies, if observed. Clinical-grade nanoformulations were tested using turbidimetric, gel-clot and chromogenic LAL. Formulations that cause a discrepancy among LAL tests were also tested by the MAT. The gel-clot LAL method cannot be relied upon to resolve discrepancies among LAL tests for certain nanoformulations. No one LAL format was shown to be optimal for all the tested clinical-grade nanoformulations. The tested alternative bioassay (the MAT) was useful for verifying LAL findings, but only for those nanoformulations not carrying/including cytotoxic drugs. Original submitted 1 March 2013; Revised submitted 13 August 2013

A strategy was described to design antimicrobial peptides (AMPs) with enhanced salt resistance and antiendotoxin activities by linking two helical AMPs with the Ala-Gly-Pro (AGP) hinge. Among the designed peptides, KR12AGPWR6 demonstrated the best antimicrobial activities even in high salt conditions (NaCl ~300 mM) and possessed the strongest antiendotoxin activities. These activities may be related to hydrophobicity, membrane-permeability, and α-helical content of the peptide. Amino acids of the C-terminal helices were found to affect the peptide-induced permeabilization of LUVs, the α-helicity of the designed peptides under various LUVs, and the LPS aggregation and size alternation. A possible model was proposed to explain the mechanism of LPS neutralization by the designed peptides. These findings could provide a new approach for designing AMPs with enhanced salt resistance and antiendotoxin activities for potential therapeutic applications.